Piscataway Campus
732-885-5555
Bensalem Campus
877-726-7663

Offshore Generator Sets

C175-16 Offshore Generator Set

  • Minimum Rating
    2619 kV·A
  • Maximum Rating
    3325 kV·A
  • Emissions
    Available in IMO Tier II/ EPA Marine Tier 2 configurations
  • Aspiration
    Turbocharged/2-stage aftercooled
Engine Specifications
Minimum Rating
2619 kV·A
Maximum Rating
3325 kV·A
Emissions
Available in IMO Tier II/ EPA Marine Tier 2 configurations
Aspiration
Turbocharged/2-stage aftercooled
Fuel System
Common Rail/EUI™
Oil Change Interval
1000.0 hr
Stroke
8.66 in
Bore
6.89 in
Displacement
5167.0 in3
Engine Control
Dual ADEM™ A4
Generator Set Control
MPD 3.0 / Cat® Alarm and Protection System
Weight
53599 lb
Aspiration
Turbocharged/2-stage aftercooled
Bore
6.89 in
Displacement
5167 in³
Fuel System
Common Rail/EUI™
Oil Change Interval
1000 h
Stroke
8.66 in
Speed
1200/1500/1800 rpm
Dimensions
Length
271.8 in
Height
110.7 in
Width
84.8 in
Height
50 Hz - 2928 (115 in) / 60 Hz - 2916 mm ( 115 in)
Length
50 Hz - 6782 mm (267 in) / 60 Hz - 6742 mm (265 in)
Width
50 Hz - 2413 mm (95 in) / 60 Hz - 2125 mm (84 in)
Capacity for Liquids
Cooling System
92.0 gal
Lube Oil System
250.0 gal
Cooling System
92 gal (US)
Lube Oil System
250 gal (US)
  • Air Inlet System
    • Dual turbochargers
    • Corrosion-resistant aftercooler core
    • Air cleaners — single or dual element
  • Exhaust System
    • Dry exhaust manifolds with thermo-laminated heat shields
    • Dual turbochargers with water-cooled bearings and thermo-laminated heat shields
    • Vertical exhaust outlet
    • Flange and exhaust expanders
  • Cooling System
    • Separate-circuit-aftercooler (SCAC) and jacket water (JW) circuit cooling system
    • Gear-driven centrifugal pumps, one for each circuit
    • SCAC electronic thermostat, outlet-controlled with aftercooler inlet temperature sensing
    • JW electronic thermostat, outlet-controlled with outlet temperature sensing
    • Engine oil cooler in JW circuit
  • Fuel System
    • Cat common rail high-pressure fuel system with electronically controlled unit injectors
    • Duplex primary fuel filter with water separator
    • Duplex secondary/tertiary fuel filters
    • Electric fuel priming pump
    • Gear-driven low pressure transfer pump
    • Gear-driven high pressure transfer pump
    • Double-walled high pressure fuel lines
    • Fuel pressure, temperature, and leak detection sensors
  • Lubrication System
    • Engine-driven, gear-type oil pump
    • Integral lube oil cooler
    • Front-mounted oil drain lines and valve
    • Oil sampling valve
    • Filler and dipstick
    • Four-canister simplex oil filter
    • Prelube pump — electric, air, or custom
    • Fumes disposal with crankcase breathers
    • Crankcase explosion relief valves
  • Engine Control and Protection
    • Dual ADEM A4 engine control unit (ECU) for redundancy
    • Software monitors engine parameters and performs alarm, derate, and shutdown functions
    • Rigid wiring harness
    • Marine Power Display 3.0 (MPD 3.0)
  • Mounting
    • Inner-outer base with vibration isolators
  • Generator
    • Kato brushless permanent magnet 6P6.6-3200 HR
    • 2-bearing, close-coupled arrangement
    • 60 Hz, 600V, 0.7 PF
    • UL/CSA listed, IP23
  • Flywheel and Coupling
    • Flywheel housing, SAE No. 00
    • Flywheel, SAE No. 00
    • ABS certified, non-certified, or custom-coupling and coupling mounting
    • Free-standing or close-coupled generator set arrangements
  • Starting System
    • Turbine air starter or
    • Dual electric starting motors or
    • Air and electric starting motors (redundant)
  • General
    • Power distribution box — 24V or custom
    • 20A battery charger
    • Cat yellow paint
    • Offshore oil field sub-base
    • Integral spring isolators with limit stop
    • Lift provisions on base
    • Oil drain extension
    • Engine length drip pan with drain
    • Torsional dampened driveline couplings
  • Air Inlet System
    • Air cleaner service indicator
  • Cooling System
    • 9 kW, 240V, 60 hz jacket water heater
    • Custom jacket water heater
  • Fuel System
    • Four canister duplex oil filter
  • Engine Control and Protection
    • Cat Alarm and Protection System
    • Communication module PL1000T/E
    • Direct-rack control
    • Thermocouples
    • Metal particle detector
    • SOLAS spray shielding
  • Mounting
    • Custom I-beam base with vibration isolators
  • Generator
    • Custom generator
  • General
    • TVA report
    • Special tests
    • Project-specific installation drawings
    • P&ID-electrical drawings
    • Spare parts kit
    • Barring group
    • Engine lifting group
    • Custom generators and radiators